Hello St. Peter! Did you know that the first federally-mandated emissions control device was introduced in the 1960’s? The Positive Crankcase Ventilation valve, or PCV valve, has been installed in MN vehicles since 1964 and represents the first legislation by the United States government to regulate harmful emissions as well as to improve performance in the country’s vehicles.

The PCV valve, as you can probably guess, is located on the crankcase. The crankcase is the lowest part of a vehicle’s engine. It houses the crankshaft and the engine oil. The crankshaft connects to the pistons that power the engine.

Pistons are pushed down when fuel is burned in an engine. This causes the crankshaft to rotate, which sends power to the transmission.  It ultimately turns the axles and causes the vehicle to move. Some of the gases released by the burning fuel squeeze around the pistons and down into the crankcase.

If the escaped gases mix with the engine oil in the crankcase, oil sludge develops. This sludge has the consistency of petroleum jelly and can cause damage by clogging up passageways in the engine. Further, escaped gases can build up pressure inside the crankcase that can blow out seals and gaskets.

Before 1964, a hose was attached to the crankcase that vented escaped gases out into the air. These gases contained about 70% unburned fuel as well as harmful emissions. The PCV valve was designed to curb these harmful emissions as well as recapture unburned fuel.

The PCV valve is a small, one-way valve that allows escaped gases to exit the crankcase. The gases are then routed into the intake system so they can be re-burned in the engine. Fresh air enters the crankcase through a breather tube to facilitate this circulation and keep the air in the crankcase clean.

The PCV valve, like most working parts on a vehicle, will wear out over time. Usually it simply gets gummed up. Preventive maintenance, including routine oil changes at Autotronics of St. Peter in St. Peter, will extend the life of the valve, but eventually it will have to be replaced. A sticking PCV valve won’t allow gases to circulate properly, which can increase pressure in the crankcase. Over time, that pressure will lead to oil leaks.

Your vehicle manufacturer recommends that a PCV valve be replaced every 20,000 to 50,000 miles (32,000 to 80,000 kilometers), depending on the vehicle and St. Peter driving conditions. It’s an inexpensive repair but may not be included in the maintenance schedule in your owner’s manual.  So if you’re looking for auto advice about the PCV valve, you may have to ask our pros at Autotronics of St. Peter.

Taking care of our PCV valve protects the environment in MN and improves vehicle performance. It’s just part of good vehicle care for St. Peter drivers and a way all of us can do our part to improve the world we live in.

Autotronics of St. Peter
111 Jefferson Avenue
St. Peter, MN 56082
507.934.9290
http://autotronicsstpeter.com

Many of us have become aware of how important it is to keep our planet’s air clean, and your vehicle has a key component that helps do just that: the catalytic converter.  It’s in the exhaust system, and its job is to superheat unburned, harmful byproducts in the exhaust, so they don’t get spewed out into the atmosphere.

There’s another important purpose the catalytic converter has: it improves your vehicle’s efficiency. 

Most of us don’t give the catalytic converter much thought until it breaks or someone steals yours, something that’s been happening much more frequently in recent years.  The reason people steal them is that catalytic converters use precious metals such as platinum, palladium, and rhodium to do their job. So, they contain valuable materials thieves can sell.

The most likely reason you will have to replace your catalytic converter is age.  The more distance your vehicle travels and the more hours your engine runs, it’s putting wear and tear on the converter.  T

You can tell if your catalytic converter is failing by looking out for these signs:

• Smell of rotten eggs inside your cabin or outside near the exhaust
• Check Engine light is on
• Vehicle power isn’t what it used to be, or fuel economy has plunged
• Vehicle backfires

If you need a new catalytic converter, it can be replaced with an original equipment part if it’s available, or an aftermarket converter can be welded into the exhaust pipe.  It’s not uncommon for oxygen sensors to need replacing as well.  The technician will also check for other problems in your powertrain that may have contributed to your converter failing.

Check to see if an emissions test is required where you live.  If it is, you will have to have a properly functioning catalytic converter to pass it.

Autotronics of St. Peter
111 Jefferson Avenue
St. Peter, MN 56082
507.934.9290
http://autotronicsstpeter.com

Most of us know a bad muffler when we hear it.  That loud, rumbling sound is unmistakable. Did you also know you can get a ticket for driving around with a loud exhaust system?

If your exhaust system has a leak in it, it may be allowing poisonous gases inside your vehicle and could make you seriously ill (or even kill you!) if you breathe too much in.

Unfortunately, your exhaust system faces a lot of destructive forces out on the road.  Rust is the worst, and not just in colder climates where they use salt and brine as de-icers.  Exhaust systems can rust from the inside out when moisture condenses inside the pipes.  Vibrations and jolts from rough roads (and the occasional run in with a rock or a curb) can wreak havoc with exhaust systems.  Even a bad oxygen sensor can send too much fuel into the catalytic converter, and the resulting heat can wind up destroying this very expensive component.

Your exhaust system is made up of several parts, and all need to be in good shape in order for you to be sure that the gases created by your engine’s combustion get properly moved out and away from the vehicle. The good news is that many newer exhaust systems are made out of more durable materials like stainless steel.  But all exhaust systems are subjected to some of the roughest elements streets can dish out. So it’s a good idea to have your exhaust system periodically inspected and serviced.

There are a lot of parts to keep track of in an exhaust system, including the muffler, manifold, catalytic convertor, oxygen sensors and the muffler (or maybe your vehicle has more than one).  We strongly recommend having your exhaust system periodically checked so we can catch a problem before it turns into something major… and maybe dangerous.  We can recommend repair or replacement that suits your driving habits and budget. 

Oh, and remember one final benefit to a tip-top-shape exhaust system.  Your vehicle will dump far less pollution into the atmosphere if it’s working the way engineers designed it.  We’ll all breathe a little easier when our exhaust systems are doing their job right.

Autotronics of St. Peter
111 Jefferson Avenue
St. Peter, MN 56082
507.934.9290
http://autotronicsstpeter.com